A First Step Towards Route 66

Hello and Welcome,

We are the proud owners of a 1976 Volkswagen Transporter, equipped with a Westfalia interior (cooker, sink, fridge, etc.)

We purchased our bus with the understanding that to get the vehicle fully functional would take time and funds. Repair issues such as brakes, non-working gas gauge, missing door trim, non-working sink and cooker, welding, and multiple other issues, would have to be addressed.

Join us as we work our "rolling resto" and take aim at our ultimate goal: a 2200 mile trip to touch Route 66 in Summer of 2021, while it's still there.

Comments

Bleeding New Year

Happy New Year! After buying our bus in April '20, we replaced the rear shoes and cylinders and bled the system. Front pads seemed fine, as did hoses. We have driven the bus many miles since then with the brakes working well. My daughter took the bus to visit a neighborhood friend and reported that the brakes faded almost all the way to the floor. She was able to pump the brakes to stop. However, after the pumping the brakes were fine again. On her return, I took the bus for a test on the exact route, no issues and the brakes were fine there and back. I also tested the booster by pressing the pedal while starting and, as expected, the pedal dropped slightly - but settled well over half the available travel, as its always been. Fluid is full with no apparent leaks. The reason why seemingly good brakes would intermittently fade? Brake master cylinder - apparently, when a MC is about to fail fully, intermittent loss of pedal pressure is common. I soaked the brake pipe nuts in PB Blas...

New Distributor, New Life

The refurbished distributor finally arrived for our Volkswagen Bay Window Type 2. After a little grease and a "wiggle", the distributor dropped straight into place. I placed the pulley timing mark at 7. 5 BTDC (visually) and, using a test light, rotated the distributor until the test bulb just illuminated. I turned the key, and instant success! Bus started immediately and held a tick-over. My next step is to time with a timing light. The distributor has a single vacuum that is currently attached to the throttle unit. However, I believe that I should have a 'T' in the vacuum line that also goes to a nipple under the air box. That nipple was capped by the previous owner. For now, I will time with just the vacuum attached to the throttle unit - as it was with the previous electronic module dist. The VW Bus started first time and performed flawlessly on a 10 mile test drive. However, the tachometer's now reading roughly 1.5x higher rpms than it did when we used the ...

Wink, wink....nudge, nudge

We fitted chrome 'eyelids' to the Bus because we like the look. Check out the install video here: Before and after picture:

Volkswagen Type 2 Musings

Search This Blog